Important! We are not a permit service. We do not arrange permits for carriers. The following is for informational purposes only. Always read your permits and provisions sheets carefully. We cannot guarantee the accuracy of the information provided.
Wisconsin DOT Phone Number
608-250-4606
RESTRICTED TRAVEL
Travel is restricted on major holidays and holiday weekends, with some variations according to size.
OPERATING TIME
Loads not exceeding 12′ wide, 13’6″ high, or 100′ long may run 24/7, except between 4:00 PM to 11:00 PM on Sunday, and between 4:00 PM to 11:00 PM between the fourth Sunday in May and Labor Day. Greater than these dimensions may not run during hours of darkness, not from Noon on Saturday until sunrise on Monday, and not between 4:00 PM to 11:00 PM between the fourth Sunday in May and Labor Day. Overweight only can travel 24/7, including weekends and holidays, unless otherwise stated on the permit.
PERMITS
Wisconsin oversize permits are valid for fourteen consecutive days. Must have a permit prior to entering the state.
LEGAL DIMENSIONS
Length:
53′ semi-trailer on designated highways (provided kingpin to center of rear tandem or to center of last axle of a Tridem does not exceed 43′)
48′ semi-trailer and 75′ overall on other roads
Width: 8’6″
Height: 13’6″
Weight: 80,000 Gross
Single – 20,000
Tandem – 34,000
Tridem – 42,000 (43,000 with 9′ of spacings)
ROUTINE PERMIT LIMITS
Length: No set limit
Width: 16′
Height: Depends on routes
Weight:
Single – 30,000 (with 4 tires)
Tandem – 65,000
Tridem – 81,000
Loads exceeding 16′ or 150,000 pounds are considered as Super Loads.
ESCORTS
Length: Usually not required
Width: Over 15′ – 1 escort
Height: Usually not required, depends on routes
SEASONAL LOAD (WEIGHT) RESTRICTIONS: Spring thaw overweight restrictions usually go into effect on “Class 2 Roads” from approximately early March until mid-May. Interstates and US Highways are normally not restricted. The start date varies from year to year.
MISCELLANEOUS: Farm equipment delivered to a Wisconsin destination and not using any Interstate routes does not need a permit but can only run on Monday through Thursday and up to 2:00 PM on Friday.
SIGNS, FLAGS & LIGHTS: “Oversize Load” signs required when the vehicle/load exceeds 10′ wide or is overlength. They must be lit up to run at night. Flags (18″ square) are required at the front and rear corners of overwidth loads, and at the widest point of any load which is more than 4″ wider than the vehicle or the front or rear corners of the load.